Ultrastable Catalyst Could Lead to More Efficient and Cheaper Production of Propylene From Propane
On the surface of the newly developed catalyst (PtGa-Pb/SiO2), Pt1 sites remain exposed to facilitate catalytic reaction while Pt3 sites (and Ga3 sites) shown with triangles are blocked by Pb. (Yuki Nakaya, et al., Nature Communications, June 5, 2020). Credit: Yuki Nakaya, et al., Nature Communications, June 5, 2020
A group of Japanese scientists has developed an ultrastable, selective catalyst to dehydrogenate propane — an essential process to produce the key petrochemical substance of propylene — without deactivation, even at temperatures of more than 600°C.
Propylene is an important raw material for plastics, synthetic rubber, surfactants, dyes and pharmaceuticals. In recent years, there has been an increased demand for propylene produced from cheaper, shale-originated propane. Reaction temperatures of more than 600°C are necessary to obtain sufficient propylene yields, but under these harsh conditions, severe catalyst deactivation is inevitable due to carbon deposition and/or sintering. Catalysts in practical use, therefore, must be regenerated either continuously or in short cycles, making the process inefficient and costly.
In the present study, the group, including a master’s student Yuki Nakaya and Associate Professor Shinya Furukawa at Hokkaido University’s Institute for Catalysis, focused on the intermetallics (PtGa) of platinum (Pt) and gallium (Ga), which have unique properties and structures. PtGa has a high thermal stability and its structure does not change even under high temperatures. It is also known to have two kinds of catalytic sites on its surface: a site with three Pt atoms (Pt3 site) and one with single-atom-like isolated Pt (Pt1 site).
Yuki Nakaya (left) and Shinya Furukawa (right) of the research team. Credit: Hokkaido University
The group hypothesized that if the Pt3 sites — which facilitates carbon deposition in addition to producing propylene — is disabled to allow only the Pt1 sites to function, the catalyst will be ultrastable and also able to prevent carbon deposition. The group tried various metals and catalyst synthesis methods to make only the Pt1 site function.
The newly developed catalyst (PtGa-Pb/SiO2), which is silica-supported and made by adding lead (Pb) to the surface of PtGa, exhibits no deactivation when dehydrogenating propane at 600°C. The catalyst maintained the initial conversion rate of 30 percent for 96 hours after the reaction started, which is significantly more stable than conventional catalysts. Propylene selectivity is as high as 99.6 percent with few side reactions, including carbon deposition. The results showed that this catalyst produces the world’s best performance at temperatures of 580°C or higher. In particular, its life span is more than twice as long as the previous reported record longevity for such catalysts. Furthermore, the catalyst can be produced as cheaply as conventional catalysts. Their structural analysis confirmed Pt3 sites, not Pt1 sites, were covered and disabled by Pb, as they expected.
“Our finding could lead to a more efficient and cheaper industrial process to produce propylene from propane without the need for catalyst regeneration — which is far superior in selectivity and stability than conventional ones,” says Furukawa. “Moreover, this method could be applicable to dehydrogenation of other lower alkanes such as ethane and isobutane, thus contributing to the petrochemical industry’s development.”
Reference: “Single-atom Pt in intermetallics as an ultrastable and selective catalyst for propane dehydrogenation” by Yuki Nakaya, Jun Hirayama, Seiji Yamazoe, Ken-ichi Shimizu and Shinya Furukawa, 5 June 2020, Nature Communications.
- Advanced Gas Membrane Materials Designed to Reduce Industrial Carbon Emissions
- Levitation That’s No Trick: Scientists to Perform “Touchless” Chemical Reactions
- Results of an Experiment by USC Student May Rewrite Chemistry Textbooks
- Scientists Rip Apart Water Molecules More Efficiently With New Catalysts
- Chemists Achieve Breakthrough in the Synthesis of Graphene Nanoribbons
- New Eco-Friendly, Flame-Retardant Carbon Plastic Is Ideal for Recycling
- New Method Uses Centrifugal Force to Decelerate Particles, Creates New Research Opportunities
- Researchers Retrieve Water and Sediment Samples from Subglacial Lake Whillans
- Record-Number of US States Growing Hops As Craft-Beer Booms
- Gravity Alone Does Not Explain the Distribution of Stars in Crowded Clusters
- NASA’s Cassini Catches a Glimpse of Venus from Saturn Orbit
- Signs of Winter on Titan – Ice Cloud Forming at Titan’s South Pole
- Hubble Views Elliptical Galaxy NGC 2768
- New Layer of the Human Cornea Discovered